Ein „Drivingrange" ist ein Platz, auf
dem ein Golfspieler seine langen Schläge üben kann, er besteht aus einem
Gelände
mit Abschlagplätze.
Die Drivingrange-Golfbällen
werden von hier abgeschlagen und landen dann auf dem Drivingrange.
Diese Bälle werden
zu bestimmten Zeiten eingesammelt und dem übenden Golfspieler wieder zur
Verfügung
gestellt, meistens über
den Ballausgabeautomaten mit Münzeinwurf
Wenn das Gelände,
auf dem die Golfbälle
landen durch Regenfall nass wird, bleiben Sand, Lehm oder abgernähte Grasstückchen an
den Bällen
kleben. Die Bälle
werden gewaschen, um Störungen
im Ausgabeautomat zu vermeiden und, um dem Spieler saubere Bälle zur
Verfügung
zu stellen.A "driving range" is a place on
that a golfer can practice his long strokes consists of one
terrain
with tees.
The driving range golf balls
are knocked off from here and then land on the driving range.
These balls will be
collected at certain times and returned to the practicing golfer
disposal
posed, mostly about
the ball dispenser with coin slot
If the terrain,
on which the golf balls
if rain lands, sand, clay or cut pieces of grass remain
the balls
glue. The balls
are washed out to interference
in the dispenser and to give the player clean balls
disposal
to deliver.
Es gibt mehrere Typen von Waschanlagen für Golfbälle, zum
Beispiel die Range King IC901 Spiral Ball Washer und die Range Servant
Ball Washer BT 1250 und die BT 1950. Der Nachteil dieser Anlagen
ist, dass sie sehr langsam arbeiten, viel Wasser verbrauchen, störungsanfällig sind
und verhältnismäßig teuer.
Damit die Bälle
nicht von Hand in den Behälter
des Ballausgabeautomaten gelegt werden müssen, muss man eine Transportanlage
für die
Bälle haben,
welche die Bälle
von der Bodenfläche
zur Oberseite des Behälters
des Ballausgabeautomaten führt,
zirka 1,75 Meter hoch. Es gibt auch Transportanlagen für Golfbälle, wie
die Range King 1A301 Elevator, diese befördert die Golfbälle mit
einem Förderband
auf eine höhere
Ebene.There are several types of golf ball washers, for
Example the Range King IC901 Spiral Ball Washer and the Range Servant
Ball Washer BT 1250 and the BT 1950. The disadvantage of these systems
is that they work very slowly, consume a lot of water, are prone to failure
and relatively expensive.
So the balls
not into the container by hand
the ball dispenser must be placed, you need a transport system
for the
Have balls
which the balls
from the floor area
to the top of the container
the ball dispenser leads,
about 1.75 meters high. There are also transportation facilities for golf balls, such as
the Range King 1A301 Elevator, which also carries the golf balls
a conveyor belt
to a higher one
Level.
Mit dieser Erfindung wird beabsichtigt,
einen neuen Typ einer Golfballwaschanlage anzubieten, der die zwei
abengenannten Funktionen kombiniert und die obengenannten Nachteile
nicht aufweist. Die Anlage besteht aus einem Gehäuse, welches die gleiche Höhe hat wie
die gewünschte
Förderhöhe der Golfbälle. In
diesem Gehäuse
sind mehrere rotierende Bürsten
montiert. Diese werden durch eine Führungsschiene abgeschirmt,
die so geformt ist, dass sie dem Golfball an der aufwärtsdrehenden
Seite der Bürste
genügend
Platz lässt.
Dieser Zwischenraum beträgt
etwa 2/3 vom Durchmessers eines Golfballs. Die restlichen 1/3 ergeben
sich durch die Verformung der Bürsten.
Die sich nach unten drehende Seite der Bürste ist komplett abgedeckt.
Der Ball wird durch die unterste Bürste aus dem Spülkasten
aufgenommen, wobei der Ball bei der Übernahme durch die nächste Bürste jedes
Mal wieder die entgegengesetzte Richtung annimmt und durch den Trägheitswiderstand des
Balls in diesem Augenblick, ein zusätzlich bürstender Effekt entsteht; gleichzeitig
wird der Ball nach oben gebürstet.This invention is intended to
to offer a new type of golf ball washer, the two
Aben mentioned functions combined and the above disadvantages
does not have. The system consists of a housing, which has the same height as
the desired
Head of the golf balls. In
this housing
are several rotating brushes
assembled. These are shielded by a guide rail,
which is shaped so that it is on the golf ball at the upward rotating
Side of the brush
enough
Leaves space.
This gap is
about 2/3 the diameter of a golf ball. The remaining 1/3 result
itself through the deformation of the brushes.
The downward rotating side of the brush is completely covered.
The ball is removed from the cistern by the bottom brush
recorded, the ball being taken over by the next brush each
Again takes the opposite direction and due to the inertia resistance of the
Balls at that moment, an additional brushing effect occurs; simultaneously
the ball is brushed upwards.
Durch eine Reihe von Sprühdüsen, die
genau unter der obersten Bürste
angebracht sind, entsteht ein nach unten gerichteter Gegenstrom
von Wasser. Die Bälle
gelangen unten in das schmutztigste Wasser, und je weiter sie nach
oben kommen, desto sauberer werden sie gebürstet.Through a series of spray nozzles that
just under the top brush
attached, there is a countercurrent directed downwards
of water. The balls
get down into the dirtiest water, and the farther they go
come up, the cleaner they are brushed.
Die Erfindung wird hier an Hand des
folgenden Beispiels beschrieben. Die Golfbälle, die gereinigt werden müssen, werden
in den Spülkasten
(9) gebracht. Beim Einschalten der Anlage nimmt die Bürste (1) über die
gesamte Breite eine Anzal von Golfbällen aus dem Spülkasten
und transportiext diese bürstend
gegen die Führungsschiene
(11) nach oben zu Bürste
(2). Am Punkt (12) übernimmt Bürste (2) den Golfball,
wobei der Golfball eine andere Drehrichtung annimmt, was wiederum
einen verstärkten Bürsteffekt
zur Folge hat. Die Bälle
werden so anschließend
von allen darüber
angebrachten Bürsten übernommen,
weiter gereinigt und bis zur gewünschten
Höhe transportiert
und durch eine Auswurfrinne (13) in den Behälter des
Ballausgabeautomaten transportiert. Über die Sprühdüsen (14) wird beim Einschalten
der Anlage Wasser zugeführt,
das die Bürsten
und Bälle
spült und
zusammen mit dem entfernten Schmutz abläuf.The invention is described here using the following example. The golf balls that need to be cleaned are put in the cistern ( 9 ) brought. When the system is switched on, the brush ( 1 ) across the entire width a number of golf balls from the cistern and brushes them against the guide rail ( 11 ) up to brush ( 2 ). At the point ( 12 ) takes over brush ( 2 ) the golf ball, the golf ball adopting a different direction of rotation, which in turn results in an increased brushing effect. The balls are then taken over by all the brushes placed above them, further cleaned and transported to the desired height and through a discharge chute ( 13 ) in the container of the ball dispenser. Via the spray nozzles ( 14 ) water is supplied when the system is switched on, which rinses the brushes and balls and runs off together with the removed dirt.
AUSZUGABSTRACT
Eine Wasch- und Transportanlage für Golfbälle, mit
der die Golfbälle
durch die rotierenden Bürsten
(1 bis 8) nicht nur gereinigt werden, sondern gleichzeitig
auf eine entsprechende Höhe
transportiert werden, sodass Sie ohne weitere Hilfsmittel in einen
Ballbehälter
gelangen und der reinigende Wasserstrahl der Düsen (14) in entgegengesetzter
Richtung über
die Bälle
strömt,
sodass die schmutzigsten Bälle
mit dem schmutzigsten Wasser gewaschen werden und die Bälle, je
sauberer sie werden, auch mit saubererem Wasser gespült werden;
sodass mit wenig Wasser ein ausgezeichneter Reinigungseffekt erzielt
wird.A washing and transport system for golf balls, with which the golf balls can be moved through the rotating brushes ( 1 to 8th ) not only be cleaned, but also transported to an appropriate height at the same time, so that you can get into a ball container without further aids and the cleaning water jet of the nozzles ( 14 ) flows over the balls in the opposite direction, so that the dirtiest balls are washed with the dirtiest water and, the cleaner they become, the balls are also rinsed with cleaner water; so that an excellent cleaning effect is achieved with little water.